Effect of Strength Properties on Concrete by Partial Replacement of Coarse Aggregate with Waste Cuddapah Stones
|International Journal of Engineering Trends and Technology (IJETT)||
|© 2017 by IJETT Journal|
|Year of Publication : 2017|
|Authors : Rajendra D, H Gokulram
|DOI : 10.14445/22315381/IJETT-V44P244|
Rajendra D, H Gokulram "Effect of Strength Properties on Concrete by Partial Replacement of Coarse Aggregate with Waste Cuddapah Stones", International Journal of Engineering Trends and Technology (IJETT), V44(5),221-223 February 2017. ISSN:2231-5381. www.ijettjournal.org. published by seventh sense research group
Cement, fine aggregate, coarse aggregate and water are important constitutes of concrete that are obtained naturally. So we can replace new materials instead of natural sources such as M Sand, fly ash, Metakaolin, etc.Aim of this project is to study the strength properties of the concrete by partially replacing coarse aggregate by waste Cuddapah stones and cement (OPC) with Fly ash. This thesis covers the properties of materials and mix proportions, preparation of concrete with waste Cuddapah stones, hardened state characteristics, and influence of various parameters on hardened state concrete and utilization of various materials in the structural members. Waste Cuddapah stones (WCS) were partially replaced as coarse aggregates in 20%, 40% and 60% respectively and fly ash (FA) was partially replaced with cement by 20% respectively are casted and tested for 7 and 28 days.Fresh and hardened concrete properties are evaluated by workability test, compressive strength and split tensile test with a fixed water cement ratio 0.4. The test results were compared with the conventional concrete properties and show that there is an increase in strength of the concrete.
 A R NihithChowdary and E PremaLatha, Experimental Studies on Partial Replacement of Shabath Waste as Coarse and Fine Aggregate, International Journal of Innovative Research in Science,Engineering and Technology, Vol. 5, Issue 2, February 2016.
 V Giridhar, HSudarsana Rao and Vaishali G Ghorpade, Development of regression models for strength of ceramic waste aggregate concrete, International Journal of Emerging Trends in Engineering and Development, Vol.1, Issue 5, Dec – Jan 2015.
 G Murali, K R Jayavelu, et al., Experimental investigation on concrete with partial replacement of coarse aggregate, International Journal of Engineering Research and Applications, Vol.2, Issue 2, Mar – Apr 2012.
 Shaik AkhilMastan and V.R.Prasath Kumar, Experimental Study on Concrete by Partial Replacement of Fine Aggregate with Fly Ash and Egg Shell Powder, International Journal & Magazine of Engineering,Technology, Management and Research, Volume 2, Issue 2, February 2015.
 C Naresh, B Ajitha, et al., Workability Studies on Fibre Reinforced Concrete Using Bethamcherla Marble Stone as a Replacement of Natural Aggregate, International Research Journal of Engineering and Technology, Volume 2, Issue 4, July 2015.
 Lokesh Kumar and GautamBhadoriya, Ash and Fine Aggregate by Marble Dust, Stone Dust on Concrete Properties, International Journal of Science Technology & Engineering, Volume 2, Issue 6, December 2015.
 V Madhava, P Mani and N P N Murthy, Effect of Strength Properties on Concrete using Stone Polish Dust as Partial Replacement of Sand, International Journal of Advanced Technology and Innovative Research, Volume 7, Issue 16, November 2015.
 N VenkataRamana, C Sashidhar, et al., A technical feasibility approach to utilize the stone waste for construction works, International Journal of Innovative Research in Science,Engineering and Technology, Volume 2, Issue 8, August 2013.
 IS: 383-1970, Specification for Coarse and Fine Aggregate from Natural Sources for Concrete—Bureau of Indian Standards, New Delhi.
 IS: 516-1959, Methods of Tests for Strength of Concrete, Bureau of Indian Standards, New Delhi.
 IS: 5816-1970, Methods of Test for Splitting Tensile of Concrete Cylinders, Bureau of Indian Standards, New Delhi
cement, coarse aggregate,Cuddapah waste, fly ash, partial replacement, water